Even the best central air conditioning units can break down. But what is causing these leaks? Are there tell-tale signs to look for or ways to prevent them from happening? And if you do have a leak, what should you do about it? We have the answers to all these questions so you can take the best care of your AC.

1. The seal around the AC unit has worn down

The bulk of any air conditioning system – be it a window air conditioner, a central air conditioner or a portable air conditioner – is manufactured from non-corrosive metal. However, some parts – including the seals – are made from rubber, which is initially less prone to leaking. Over time, these rubber seals get exposed to moisture or heat, which can cause them to dry out and either break up or crack.   This can allow air and/or refrigerant to leak out – and also creates other issues. “When the seal around the compressor is compromised, debris can get into the system and cause damage,” Walter Bennett explains.  If you suspect your seal is broken, you’ll need to call out a professional to replace it. First, check your warranty and see if the work is covered. Then act fast. According to air conditioning distributors FCJ (opens in new tab), “Neglecting to do so might allow moisture in to contaminate the system.  When moisture mixes with refrigerant, an acid is formed which can break down other system components or can cause tiny pin hole leaks – a much more complex and costly repair than a simple O-ring replacement or rubber leak seal.”

2. Wires are loose or broken

“Leaks can also occur when wires inside your AC unit become loose or broken. This creates heat problems, which in turn lead to leaks,” says Walter. Wires can wear out over time, or be damaged by power outages. Again, any rewiring or diagnosis should be taken on by a professional. It can be difficult to diagnose a wiring issue, but one telltale signs is that the unit often trips out your electrics. Check your fuse box to see if the circuit breaker for your unit is set to the off position.  You can prevent wiring problems from happening by ensuring you get the unit properly installed, and then regularly maintained. 

3. Condensation or ice is forming in the cold

“In cold climates, condensation can form outside the AC unit,’ says Walter Bennett. “This then drips down and creates leaks.” Cold weather can also cause the evaporator coils to freeze. As they defrost, the water will drip down through the unit and onto the floor.  Atlanta Heating & Air Solutions (opens in new tab) recommends insulating your refrigerant lines – the pipes that transport refrigerant through your air conditioning system. “Most air conditioning systems have a low-pressure and a high-pressure refrigerant line. Of these two lines, you typically only need to insulate the former.  “Insulating the high-pressure refrigerant will protect against condensation. At the same time, it will ensure that the refrigerant remains at an appropriate pressure while it’s being carried to the condenser unit.”

4. The drain line is clogged

“One of the most common reasons for an AC leak is a lack of maintenance,” says Ryan Collier, an HVAC expert and company Director of Heat Pump Source (opens in new tab). “When your AC unit isn’t properly maintained, it can lead to a build-up of dirt and debris, which can eventually clog the drain line. This can cause water to back up and leak out of the unit.” To make sure this doesn’t happen, the US Department of Energy (opens in new tab) recommends that you “Occasionally pass a stiff wire through the unit’s drain channels”. If you suspect your condensate drain line is clogged and that the unit needs to be opened up, it’s time to call a registered HVAC technician. 

5. Poor installation

“If your AC unit wasn’t installed properly, it could be the cause of your leaks,” says Ryan Collier. “Make sure to hire a qualified professional to install your AC unit to avoid this issue.”

6. There’s a a crack in the unit

“Over time, wear and tear can cause cracks in your AC unit, which can lead to leaks,” says Ryan Collier. “Inspect your unit regularly for any cracks or damage.” If you do find a crack, it’s wise to call an engineer straightaway to see if it can be repaired, or if you’ll need a replacement. It’s not a good idea to patch up the crack – not least because the substance leaking from it might not be water, but toxic refrigerant. A home repair may also void your warranty. 

What can I do to stop my air con from leaking?

Every expert we approached recommended a regular schedule of maintenance, based on your system’s operating manual and our guide to how to clean an air conditioner. “Maintenance can be fairly simple,” Shuhdi explains. “You should replace the air filter regularly – typically every 30 to 60 days. You also need to keep the condenser coil clean.” You may find that if it’s hot and the unit is working hard, you may need to change the filter more regularly – as often as once a month.  You can clean your condenser coils using a brush and removing larger bits of debris by hand. You can then vacuum the coils and clean them with a spray solution of mild detergent and water. Always disconnect the power to your unit before you take on any cleaning.  “Maintaining a clean air filter prevents impurities such as dust from accumulating on the evaporator coil and ensures proper air flow. Maintaining a clean condenser prevents high refrigerant pressure caused by improper air flow,” adds Shuhdi.

What should I do if my AC springs a leak?

Shuhdi Alrishood is an assistant director of education at the MIAT College of Technology, and trains HVACR technicians.  “Repairs should be done only by a certified technician for safety reasons,” he says. “The EPA requires AC technicians to obtain a section 608 certification, and local state regulations might require either a mechanical contactor license, or that a technician work for a licensed contractor in order to perform installations and service.” Shuhdi explains what you should expect an engineer to do. Discover more guides to air conditioners… Best thru wall air conditioners Best ductless air conditioners Tower fan vs. window air conditioner: Which is more cost efficient?